MIL-T-62223 Truck, Mobile Blood Donor And Component Laboratory, Tilt Cab, Diesel Or Gasoline Engine Driven, 24,000 Pounds Gvw, 4X2, CommercialThis specification covers a completely self-contained, mobile, self-propelled unit, designed to serve as a combination mobile blood component processing laboratory and three-bed donor facility. The vehicle shall be diesel or gasoline engine driven, four-wheel, two rear wheel drive, having minimum gross vehicle weight GVW of 24,000 pounds and shall be equipped with a tilt cab, a 30 kilowatt kW auxiliary generator and a 4 kW auxiliary generator. The body shall be fully air conditioned and heated. Vehicles procured under this specification are commercial items which shall be warranted by the manufacturer as specified in procurement documents.

Pages 1 - 2 - 3 - 4 - 5 - 6 - 7 - 8 - 9 - 10 - 11 - 12 - 13 - 14 - 15 - 16 - 17 - 18 - 19 - 20 - 21 - 22 - 23 - 24 - 25 - 26 - 27 - 28 - 29 - 30 - 31 - 32 - 33 - 34 - 35 - 36 - 37

MIL-T-62223B(AT)

temperature readout from minus 5°F (-20°C) to plus 104°F (40°C) at full speed, adjustable dynamic braking, electric tachometer, pilot lights, temperature control and indicator.  Units to operate from 230 volts ac, 60 Hz, single phase, 25-ampere

vehicle supply.  Units shall be equipped with 0 to 30 minute timers.

(c)   Sink and permanently mounted recreational vehicle style toilet, installed on

streetside.  The sink and toilet shall include a 14-gallon capacity polyethylene

holding tank for out-of-sight, below-floor installation with either bottom or end drain

and shall include fittings and connectors with disposal hose section (see 3.5.9). (d)   Opaque curtain to enclose sink and toilet with track at ceiling.

(e)   A lab counter surfaced with Formica or equal, installed across rear bulkhead above generator compartment.  With storage cabinets between top of counter and top of

insulated recessed generator compartment if space permits.

(f)    Storage cabinets with sliding doors and positive latches installed at ceiling above

counter.

(g)   A hinged Formica or equal, surfaced folding counter mounted on inside of

emergency door.

(h)   A Jewett Model CT-1 or equal, blood bank refrigerator shall be installed on the

counter across the rear bulkhead.  The refrigerator shall be equipped with temperature monitor and automatic controls factory set to produce and maintain a temperature of 2°C to 4°C.  The refrigerator shall include a 7-day chart recorder. Insulation shall be installed, if required, to prevent excessive heat transfer from the engine generator set to the blood bank refrigerator.

(i)    An access door for centrifuge service and removal shall be provided within the

streetside wall.  The access door opening shall be of adequate size to permit easy entrance and exit for servicing and removal of the centrifuge.

(j)        Two 120-volt exhaust fans shall be installed within the wall or door for heat dissipation.  One fan shall be located behind each refrigerated centrifuge.

3.5.11  Sound system.  A sound system, including a solid state amplifier, an AM/FM radio/cassette tape recorder unit, and three ceiling-mounted speakers, shall be provided.  The amplifier shall include a microphone and cords, and connectors to connect additional sound equipment.  Speakers shall be provided with individual volume controls located to permit easy access by the operator.  The sound system shall perform satisfactorily with all equipment in operation.

22